Kia Soul: Movable Glass Replacement - Panorama Sunroof - Body (Interior and Exterior)Kia Soul: Movable Glass Replacement

Kia Soul 2014-2019 PS Service Manual / Body (Interior and Exterior) / Panorama Sunroof / Movable Glass Replacement

1.
Completely open the movable glass using the panorama sunroof switch.
2.
Remove both sides of the decoration cover (A) by pulling it in the direction of the arrow.

3.
Completely close the movable glass using the panorama sunroof switch.
4.
Adjust the height of the glass by slighty loosening the screws (A).
  
•
Be careful not to damage the screw.

5.
Carefully lift up the movable glass (A) and then remove it.

  
•
When installed the movable glass, put the tilt lever shoe (A) to the tilt lever.

6.
Install in the reverse order of removal.
  
•
After replacing the movable glass adjust the alignment if needed.
    Adjustment
    Inspect Glass Alignment 1. Inspect the alignment of the movable glass (C) that is between the front (A) and rear (B) glass and if needed adjust it. ...

    Front Glass Removal
       • In order to remove the front glass, use the tools shown in the following figure: ...

    See also:

    Good driving practices
    Never move the gear shift lever from P (Park) to any other position with the accelerator pedal depressed. Never move the gear shift lever into P (Park) when the vehicle is in motion. Be sure ...

    Rail Pressure Sensor (RPS). Specifications
    Specification ...

    Tire Removal
       • Using tires and wheel other than the recommended sizes could cause unusual handling ...