Kia Soul: ETC (Electronic Throttle Control) System. Repair procedures
Kia Soul 2014-2019 PS Service Manual / Engine Control / Fuel System / Engine Control System / ETC (Electronic Throttle Control) System. Repair procedures
Inspection
Throttle Position Sensor (TPS)
1. |
Connect the GDS on the Data Link Connector (DLC).
|
2. |
Start the engine and measure the output voltage of TPS 1 and 2
at C.T. and W.O.T.
|
ETC Motor
1. |
Turn the ignition switch OFF.
|
2. |
Disconnect the ETC module connector.
|
3. |
Measure resistance between the ETC module terminals 1 and 2.
|
4. |
Check that the resistance is within the specification.
|
Removal
1. |
Turn the ignition switch OFF and disconnect the battery negative
(-) cable.
|
2. |
Remove the resonator and the air intake hose.
(Refer to Engine Mechanical System - “Air Cleaner”)
|
3. |
Disconnect the ETC module connector (A).
|
4. |
Disconnect the coolant hoses (B) and vapor hose (C).
|
5. |
Remove the mounting bolts (D), and then remove the ETC module
from the engine.
|
Installation
|
1. |
Install in the reverse order of removal.
|
Adjustment
ETC module learning procedure |
When installing new ETC module or re-installing it, ETC module learning
procedure must be performed.
1. |
Hold the ignition key or the start button at the IG ON position
during 5 seconds.
|
2. |
Turn ignition swich OFF and then start the engine.
|
DTC codes (P0638, P2110) might be displayed if ETC module learning
procedure does not performed after replacing ETC module.
|
ETC (Electronic Throttle Control) System. Schematic Diagrams
Circuit Diagram (M/T) (A/T) ...Manifold Absolute Pressure Sensor (MAPS). Description and Operation
Description Manifold Absolute Pressure Sensor (MAPS) is a speed-density type sensor and is installed on the surge tank. It senses absolute pressure of the surge tank and transfers the analog ...See also:
Rear Seat Cushion Cover Component Location
1. Rear seat cushion cover
...
Using the Tire Mobility Kit
1. Detach the speed restriction label (0) from the sealant bottle (1), and place
it in a highly visible place inside the vehicle such as on the steering wheel to
remind the driver not to drive too ...
Side Airbag (SAB) Module. Description
The Side Airbags (SAB) are installed inside the front seat and protect
the driver and front passenger from danger when side crash occurs. The SRSCM
determines deployment of side airbag by usi ...